Results for "under load"

Appliances Hard Professional repair required 710 👍 0

Splendide WDC7100XC Drum Bearing Repair & Replacement Guide

Splendide combo washer-dryer started making a grinding noise during the spin cycle and now it vibrates so hard it walks across the floor. Pretty sure it's the drum bearings based on the sound. Debating between a $400 repair bill and just replacing the whole unit. …more

Read answer

Engine Medium varies 378 👍 1

Newmar Motorhome Rough Ride Fix: Suspension & Air Pressure

Noticed my 2013 Newmar still rides incredibly rough through every crack and pothole even after replacing all six air bags. The ride height was never adjusted after the air bag replacement, and I'm worried I might be causing more damage or creating a safety hazard.

I upgraded from a Super C expecting a much smoother ride with the air suspension system, but this feels just as jarring. Am I missing something critical with the suspension setup? Could improper air pressure or ride height settings be causing this rough ride, and what other components should I be concerned about? I don't want to make things worse by continuing to drive it if there's a fundamental issue I'm overlooking. …more

Read answer

Solar Batteries Medium 4-6 hours for inverter replacement 326 👍 1

RV Inverter Guide: Modified vs Pure Sine Wave - Safe Power

My multimeter's out and I'm ready to tackle this RV electrical mess myself — pretty sure the inverter's the culprit but need to know where to start. I have a 2000 Winnebago Ultimate Advantage with four deep cycle house batteries and recently installed a Xantrex 758 inverter to replace my old Freedom 15 unit. The first time I tried using the inverter power while unplugged from shore power, something very strange happened - a hair dryer in the bathroom started running by itself and wouldn't shut off when I tried the switch. I had to unplug it, and the handle was warm. The hair dryer appears to be ruined now.

When I bought the Xantrex 758, I paid around $725 for what I thought was a good unit, but I'm now learning there's a difference between modified sine wave and pure sine wave inverters. I wasn't aware of this distinction when I made the purchase, and it turns out the 758 is a modified sine wave unit. I've since heard that modern electronics, especially things like residential refrigerators, computers, and sensitive electronic components, can be damaged by modified sine wave power.

I'm really concerned about potentially damaging my new residential refrigerator, stereo system, and computer equipment. Should I be worried about using this modified sine wave inverter with modern RV electronics? Is the hair dryer incident a sign that I need to upgrade to a pure sine wave unit, or are there other factors that could have caused this problem? I'm trying to understand if my current setup is putting my expensive electronics at risk. …more

Read answer

Product Ranking 8 compared

Best RV Leveling Blocks & Jacks

4.6 (9,800 reviews)

Engine Medium varies 316 👍 1

Michelin RV Tire Problems: Complete Guide & Solutions 2024

Standing in my driveway planning to tackle these serious handling issues with my new Michelin Agilis HD Z 245/70R19.5 tires on my 2018 Winnebago Vista LX 27N this Saturday — what should I check first? The RV now has 25k miles, and since switching from Goodyear tires, I'm experiencing terrible tail wag - especially when towing my 2024 Toyota Tacoma and in windy conditions.

I've tried multiple tire pressures (82 psi from door sticker, 110 psi from installer, up to 100 psi) but nothing resolves the side-to-side movement. I have several stability modifications installed (Rear Trac Bar, Aux Roadmaster Rear Swaybar, Front Roadmaster Swaybar, Koni FSD shocks), which previously helped with handling.

The movement feels like the towed truck is actually pushing the RV's rear side-to-side, making driving extremely uncomfortable. I'm within Michelin's 60-day/2500-mile buy-back period and want to understand why these tires are performing so differently from my previous set.

Could experienced RV owners help me diagnose what might be causing these handling problems? …more

Read answer

Engine Medium 2-4 hours 309 👍 0

Generac 7.5kW Diesel Generator Repair Guide - RV Troubleshooting

Planning to ignore the weird noises from our Generac 7.5kW diesel generator backfired when my wife pointed out I definitely made things worse during my repair attempt. I have a 2007 Monaco with a Generac 7.5kW diesel generator, and yesterday when I tried starting it, the battery was really weak. I probably held the starter button too long - maybe 15 seconds or so - because it was cranking so slowly and I kept hoping it would catch.

Now when I try to start it, I just get a single click and nothing happens. I'm worried I damaged something by cranking it so long with that weak battery. Should I be looking at the starter solenoid or starter motor? Is there anything I can check myself before I have to take it to a repair shop? I'd really appreciate any guidance on troubleshooting this. …more

Read answer

Engine Hard 4-6 hours 309 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Electrical Medium 2-6 hours 295 👍 1

ECM Low Battery Warning RV: Complete Diagnosis & Fix Guide

During a family trip, my 2005 Fleetwood Discovery 39S threw code 168-1 for low ECM battery voltage and went into full shutdown mode—is this dangerous with kids onboard? Engine cut out, transmission selector went dark, ABS warnings everywhere - the whole nine yards. Scared the heck out of me when it happened on the interstate!

I'm seeing this seems to be a thing with these diesel pushers, but I'm drowning in conflicting info online. Some say it's the chassis battery, others blame alternator issues, and I've even seen posts about ECM power supply problems on the Caterpillar engines. What's the actual step-by-step process to track this down? And more importantly, how do I fix it so it doesn't leave me stranded again? Really need a complete walkthrough of what causes this code and the proper repair approach. …more

Read answer

General Medium 30-60 minutes 292 👍 0

RV Liquid Spring Adjustment Guide: Setup & Tuning Tips

Three different adjustment knobs on my 2022 Tiffin Open Road 34PA's LiquidSpring suspension and I'm staring at them with zero clue about the limits.

I've got LiquidSpring suspension on all four corners, but I'm specifically wondering about the rear struts. Can I raise and lower just the rear ones independently, or am I stuck adjusting everything at once like some kind of suspension caveman? I'd love to dial in the perfect ride height and handling, but I need to know if I can fine-tune the back end separately from the front. Between the control panel and what I assume is some fancy smartphone app, surely there's a way to make this old road warrior ride like a dream without turning into a mechanical engineer, right? …more

Read answer

Engine Medium 1 hour research 274 👍 0

Fleetwood Excursion Tire Upgrade Guide: 255 to 275 Width Conversion

After upgrading my 2015 Fleetwood Excursion M-35B from 255 to 275 width tires, it started getting sketchy handling on highway turns. The current 255/70R22.5 tires are wearing out and I'd love to go wider with 275/70R22.5 for better stability, but I keep getting conflicting advice from different tire shops.

Some say it's fine, others warn about clearance issues and potential problems. I really need to know what specific measurements I should check before making this change. What wheel width do I need? How do I verify there's enough steering clearance? I don't want to buy expensive tires only to find out they don't fit properly or aren't safe for my RV's load requirements. …more

Read answer

Engine Easy N/A 260 👍 0

Ford E-350 vs E-450 Chassis: RV Fuel Economy, Power & Weight Capacity

Last weekend I felt this awful engine strain and heard sluggish acceleration sounds while test-driving a 2017 Phoenix Cruiser #2351 with its E-350 chassis and V10 engine. I'll be doing extensive western touring through mountain and plains regions, which means substantial mountain grades and wind challenges. I'm comfortable driving slowly and want to understand two key things: 1) Will this E-350 chassis handle mountain grades without major issues, and 2) What's the real-world fuel consumption like? I plan to do an initial inspection this weekend, followed by a third-party mechanical review. I'm not overly concerned about fuel economy but want to understand the actual performance limitations. I'd appreciate insights from owners who have experience with similar touring conditions on an E-350 chassis. …more

Read answer

Engine Easy 45 min 248 👍 0

Femco vs Fumoto Oil Drain Valves for RVs - Which is Better?

Looked at my mechanic's quote for a $300 professional oil change setup and something seems off—wouldn't a basic Femco or Fumoto drain valve work just fine? I've narrowed it down to Femco and Fumoto, but I'm genuinely worried about road debris damage since RVs sit lower and encounter more hazards than regular vehicles.

The thought of a drain valve getting hit by rocks or debris and causing a catastrophic oil leak on the highway keeps me up at night. I need to know which design is actually safer and more protected in RV applications. Does one have better protection features than the other? I'd rather be overly cautious than deal with a roadside emergency. …more

Read answer

Product Ranking 8 compared

Best RV Awnings & Accessories

4.5 (7,600 reviews)

Plumbing Medium 2-3 hours 213 👍 1

Dometic 310 Toilet Leaking at Foot Pedal: Complete Fix Guide

Called my weekend camping trip short because my Dometic 310 toilet has water pooling underneath, the flush mechanism sticking, AND that annoying gurgling sound happening constantly. I can see the leak between the fixed outer part and the moving pivot section when the pedal is pressed.

Already replaced the toilet valve but it's still leaking from the same spot. The inlet and outlet hoses look fine. What causes leaks at the pedal mechanism itself after the valve has been changed? …more

Read answer

Engine Easy N/A 211 👍 0

Ford V10 Triton Engine Maintenance Guide: EGR Delete vs Regular Service Tips

Spent years doing regular EGR maintenance on my old gas motorhome without issues — but this 2007 Fleetwood 31' Tioga with Ford V10 Triton has me second-guessing everything. I keep reading conflicting information about EGR delete procedures on V10 engines, and I'm worried I might make things worse if I mess with it.

Is the EGR delete modification actually necessary on this 2007 3-valve V10, or am I overthinking this? I don't want to void any warranties or create problems that weren't there before. Would I be better off just sticking to regular maintenance instead of modifications? I'm looking for reassurance that I'm taking the right approach to keep this engine running reliably for years to come. …more

Read answer

Engine Hard Not recommended 207 👍 0

Ford V10 Turbo Kit for Motorhomes: Cost, Risks & Better Alternatives

Before every camping season rolls around, I face the same dreaded reality with my Ford V10 motorhome crawling up mountain passes like a wounded turtle. What are the realistic costs involved? Are there major risks to the engine I should know about? Is this actually worth doing or should I look at other options? …more

Read answer

Ac Refrigeration Medium 45 minutes 191 👍 0

Dometic 12V Refrigerator Not Cooling on Battery Power - Complete Troubleshooting Guide

Staring at my Dometic DMC compressor refrigerator that runs perfectly on 12V DC when it's cool but stops cooling completely once temperatures hit 85°F or higher. The unit works perfectly when I'm plugged into shore power at campgrounds - everything stays cold and the freezer compartment keeps items frozen solid. However, when I'm boondocking and running solely on my RV's battery bank, the performance drops significantly. The refrigerator struggles to maintain proper temperatures, and the freezer can't keep things frozen.

I have a relatively new battery setup with what should be adequate capacity for my power needs. The batteries test fine with a multimeter when the refrigerator isn't running, but I'm wondering if there's something I'm missing about power requirements or electrical connections. I've heard that 12V compressor refrigerators can be pretty demanding on battery systems, but I'm not sure what specific issues to look for.

What are the most common causes when a 12V Dometic compressor refrigerator works fine on shore power but fails to cool properly when running on batteries? I want to troubleshoot this systematically before calling in a technician. …more

Read answer

Loading more Q&A...

You've seen all 292 Q&A articles!