Results for "screws"

Ac Refrigeration Medium 45 minutes 488 👍 0

RV AC Making Loud Humming Noise? Fix Compressor Not Starting

Somewhere above my head, there's this loud, relentless humming grinding through the RV whenever I flip on the rooftop AC — compressor won't start but the fan spins fine.

I've been dealing with this for days now and it's driving me crazy - especially with the heat we've been having! The humming is so loud that I'm worried something might be seriously damaged. I really hope this is something I can fix myself rather than having to call out a repair tech. What could be causing a compressor to hum loudly but not start up? …more

Read answer

Exterior Hard 4-8 hours 372 👍 0

How to Repair RV Roof Soft Spots: Fix Water-Damaged Wood Step-by-Step Guide

My RV roof has had this squishy soft spot right next to the roof vent ever since we got hammered by that nasty rainstorm last month. When I step on that area, it feels spongy and I can tell there's water damage underneath the rubber membrane.

I'm pretty sure water has been leaking through the vent area and rotting the plywood underneath, which seems to be about a hand-sized area. I want to cut the rubber membrane back, replace the damaged wood, and then reseal it properly.

Should I be worried about the structural integrity? What type of materials should I use for the replacement wood, and how do I properly reseal everything to prevent this from happening again? I'm thinking of folding back the rubber, replacing the damaged section of wood, and then resealing the membrane over the new wood. …more

Read answer

Plumbing Medium 2-3 hours 290 👍 1

Dometic 310 Toilet Leaking at Foot Pedal: Complete Fix Guide

Called my weekend camping trip short because my Dometic 310 toilet has water pooling underneath, the flush mechanism sticking, AND that annoying gurgling sound happening constantly. I can see the leak between the fixed outer part and the moving pivot section when the pedal is pressed.

Already replaced the toilet valve but it's still leaking from the same spot. The inlet and outlet hoses look fine. What causes leaks at the pedal mechanism itself after the valve has been changed? …more

Read answer

Product Ranking 8 compared

Best RV Propane Accessories

4.5 (11,200 reviews)

Exterior Medium 2-3 hours 255 👍 1

How to Replace RV Slide Topper Fabric: Complete DIY Guide

I pulled into three different campsites this month and my torn slide topper is eating through my gear faster than I can replace it. I've never done anything like this before and I'm worried I might damage the whole mechanism or make things worse.

Can I actually replace just the fabric portion safely, or should I bite the bullet and have the entire assembly replaced by a professional? I'm also concerned about costs - I'm hoping this won't break the bank. If it is something I can do myself, how difficult is it really? I don't want to get in over my head and end up with a bigger problem than I started with.

Can you help me understand the best approach for my specific situation? …more

Read answer

Ac Refrigeration Medium 45 minutes 248 👍 0

How to Fix a Squeaking Dometic Fan-Tastic Roof Fan in Your RV

Looked up at my Dometic Fan-Tastic roof fan squeaking loudly above my kids' beds—is this dangerous or could something actually break and fall on them? The fan blades aren't hitting the housing, so that's not the issue. What are the most common causes of squeaking in these roof fans? Is this something I can fix myself with basic maintenance, or does it usually require replacing parts like bearings or the motor? …more

Read answer

General Hard 45-60 min 239 👍 0

How to Remove Firefly RV Control Panel: Complete DIY Guide

Our 2019 Fleetwood Discovery LXE has a malfunctioning Firefly multiplex control panel that needs to be completely removed. I've been putting this off for months because I keep hearing horror stories about people cracking their panels or damaging the surrounding woodwork during removal.

I need to access the back of the unit for some electrical work, but I'm honestly terrified of breaking something expensive. The panel seems to be mounted flush with no obvious screws or clips visible from the front. I've searched everywhere but can't find a complete walkthrough that covers the preparation, actual removal process, and how to get everything back together properly.

Can someone please provide a detailed DIY guide that covers all the steps? I'm willing to take my time and do this right - I just need to know the proper technique so I don't end up with a broken control panel or damaged wall. …more

Read answer

Ac Refrigeration Medium 2-3 hours 237 👍 0

Dometic RV AC Not Cooling? 5 Common Fixes for Air Conditioner Troubleshooting Guide

Walked out to my RV this morning trying to decide between calling a repair tech or troubleshooting my Dometic Brisk Air rooftop AC myself since it's showing weird operational issues. The compressor engages and fan motor operates normally, but the unit fails to produce cold air output. Temperature differential across the evaporator coil is minimal.

Unit functioned properly through previous cooling season with no apparent issues. Current symptoms include normal airflow volume but inadequate cooling capacity. What systematic diagnostic procedure should I follow to identify the root cause? Looking for a methodical troubleshooting sequence that addresses the most probable failure points in order of likelihood. …more

Read answer

Electrical Easy 30 minutes 233 👍 0

RV 12V Auto Reset Breaker Size Guide: 30A, 40A, 50A Selection

Opened up my RV this morning to prep for our two-week cross-country trip tomorrow and the electrical system keeps tripping the breaker every time I run basic appliances! My RV's entire 12V system just died completely - no lights, no water pump, nothing. I've checked everything I can think of and I'm pretty sure it's the auto reset breaker that's failed.

I have a WFCO converter/charger setup with dual 6V batteries, but I can't get underneath right now to read what's stamped on the current breaker. I need to order a replacement but I'm not sure what amperage to get. I keep seeing 30A, 40A, and 50A options online but I don't want to guess wrong and either undersize it or waste money.

What's the typical auto reset breaker size for this type of setup? Is there a standard that WFCO usually pairs with dual 6V battery systems? …more

Read answer

Plumbing Medium 1-4 hours 218 👍 0

How to Fix RV Fresh Water Tank Leaks: Complete Diagnosis & Repair Guide

Nobody warned me how tricky RV fresh water tank leaks could be — got my tools ready and determined to fix this dripping mess under my trailer myself. The dripping was pretty steady at first but seems to have slowed down overnight to just occasional drops. My tank gauge still shows full, so I don't think it's completely emptying out.

I can see there's an underbelly cover that would need to come down to access everything underneath, but I'm hoping maybe there are some easier spots I should check first? I'd rather not tackle removing panels if I don't have to - any guidance on where these leaks typically start would be really helpful, especially near the drain valve! …more

Read answer

Exterior Medium 2-4 hours 214 👍 0

Fix Cracked Dometic RV AC Covers & Roof Vents

Already tried following a YouTube tutorial to fix the cracked Dometic air conditioner cover on my 2022 East to West 1900MMK travel trailer but somehow made the crack even worse. What are my repair options - can I fix the crack or should I replace the whole cover?

Also dealing with a broken cap on the roof tank vent. I'm curious about material choices - I've noticed galvanized steel can rust, while PVC seems to degrade in sunlight. What are the pros and cons of different vent cap materials? What's a reasonable price range for replacement?

Looking for practical solutions for both issues. …more

Read answer

Solar Batteries Medium 2-4 hours 213 👍 0

How to Upgrade Progressive Dynamics Converter for Lithium RV Batteries Safely

Got a 15-year-old Progressive Dynamics converter that's starting to throw fault codes with my new lithium setup — worth upgrading or try making it work? I have a 2006 Lance 915 cabover that I recently upgraded with 2-200 watt Bouge solar panels and 2-100ah SOK lithium batteries.

The problem is I'm still running the original Progressive Dynamics converter charger that came with the RV, and I've learned it's not designed for lithium batteries. I'm worried about damaging my new battery investment.

What are my options for upgrading? I'm not sure if I need to replace the whole converter unit or if there's some kind of upgrade kit available. Any advice would be really appreciated since I don't want to mess this up! …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Solar Batteries Medium 2-3 hours 209 👍 0

RV Solar Panel Z Bracket Installation: Drill vs Adhesive Mounting Guide

Ready to mount solar panels on the roof but torn between drilling through the fiberglass with Z-brackets or using VHB tape adhesive mounts. Terrified of roof leaks from drill holes but also worried the adhesive won't hold at highway speeds. Which mounting method actually holds up long term? …more

Read answer

Appliances Medium 2-4 hours 204 👍 0

RV Water Heater Not Hot Enough: Fix Lukewarm Water Issues

Looked forward to our two-week cross-country trip starting tomorrow until I discovered my RV water heater that used to produce scalding hot water now barely gets lukewarm. Both the electric and gas functions appear to be working - I can hear the gas igniting and see the electric indicator light - but the water temperature just won't get hot enough for a decent shower.

I've been dealing with this for weeks now and it's driving me crazy. The water gets warm, but nowhere near the hot temperatures I used to get. Is this a common problem with RV water heaters? What are the most likely culprits when you're getting lukewarm water instead of hot? I really need to figure out what's causing this and how to fix it before my next camping trip. …more

Read answer

Exterior Hard 2-4 hours 199 👍 0

How to Fix RV Garage Door Delamination: Complete Repair Guide

Finally facing the inevitable with my 1994 Fleetwood Jamboree Rallye garage doors that are 30 years old and completely delaminating at the seams — repair or replace? The extruded aluminum frame corners that are supposed to be screwed together are failing because the screws keep breaking under stress. What started as minor separation has now progressed to the point where the structural integrity of the entire door system is compromised.

I've noticed that not only are the corner joints failing, but the door panels themselves seem to be separating from their backing material, and the weather seals around the perimeter are starting to pull away as well. The doors don't close properly anymore, leaving gaps that let in water and debris. I'm concerned about further damage to the garage area and contents if I don't address this comprehensively.

I need a complete repair approach that addresses the delamination issue, reinforces the structural components, and replaces the failing seals. Simply adding corner braces feels like a band-aid solution, and I'm worried about drilling out the broken screws without causing more damage to the aluminum frame. What's the proper way to tackle this type of comprehensive garage door repair on an older RV? …more

Read answer

Ac Refrigeration Medium 2-3 hours for diagnosis, professional repair likely needed 197 👍 0

Coleman Mach AC Fuse Blows With Battery On - Rockwood Fix

Found out the hard way that the previous owner of my 2019 Rockwood Minilite 2509s left me with a Coleman Mach AC that blows fuses instantly when I flip on the battery. The AC fuse blows instantly when I turn on the battery disconnect, before the AC is even activated. The fuse literally blows before it's completely seated in the panel.

This began two weeks ago without warning - the system had been functioning normally prior to this. Initial fuse replacement provided temporary operation, but the problem returned on the next trip with the fuse already blown upon arrival.

Given the immediate fuse failure with just battery power connected, what type of electrical fault would cause this symptom pattern in a Coleman Mach unit, and what's the most likely location of the problem in the AC circuit? …more

Read answer

Loading more Q&A...

You've seen all 115 Q&A articles!