Results for "power-gear"

Appliances Hard Professional repair required 710 👍 0

Splendide WDC7100XC Drum Bearing Repair & Replacement Guide

Splendide combo washer-dryer started making a grinding noise during the spin cycle and now it vibrates so hard it walks across the floor. Pretty sure it's the drum bearings based on the sound. Debating between a $400 repair bill and just replacing the whole unit. …more

Read answer

Plumbing Medium 2-4 hours 533 👍 9

RV Water Pump Losing Prime: Troubleshooting & Winterization

Got a 2022 Tiffin Open Road 34PA with a water pump that keeps losing prime during winterization — about to buy a replacement but wondering if I'm throwing money at the wrong problem? I can get it back by quickly opening and closing one of the lowest drain valves, but then it just loses prime again after a while. This has happened on other RVs I've winterized too, but it's particularly stubborn on this Tiffin.

I'm suspecting it might be the inline check valve next to the pump or maybe the one behind the Truma hot water heater, but I'd love some guidance on proper diagnosis. What are the most common causes of prime loss during winterization, and what's the best way to troubleshoot and fix this? I want to make sure I'm covering all my bases for winter storage prep. …more

Read answer

Engine Medium 2-6 hours 466 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Electrical Medium 2-6 hours 389 👍 4

RV Electrical Problems: 12V & 120V Troubleshooting Guide 2024

Around $500 in parts later — replaced the main breaker, cleaned all connections, checked the transfer switch — my 2007 Holiday Rambler Admiral SE still won't recognize shore power.

I'm pretty sure 110V is making it to the rig since I can measure it, but somewhere between the plug and my appliances, something's not happy. Energy management panel is dark too. What's the logical troubleshooting order here? I keep hearing about transfer switches and breaker panels but honestly don't know where to start without making things worse! …more

Read answer

Solar Batteries Medium 4-6 hours for inverter replacement 326 👍 1

RV Inverter Guide: Modified vs Pure Sine Wave - Safe Power

My multimeter's out and I'm ready to tackle this RV electrical mess myself — pretty sure the inverter's the culprit but need to know where to start. I have a 2000 Winnebago Ultimate Advantage with four deep cycle house batteries and recently installed a Xantrex 758 inverter to replace my old Freedom 15 unit. The first time I tried using the inverter power while unplugged from shore power, something very strange happened - a hair dryer in the bathroom started running by itself and wouldn't shut off when I tried the switch. I had to unplug it, and the handle was warm. The hair dryer appears to be ruined now.

When I bought the Xantrex 758, I paid around $725 for what I thought was a good unit, but I'm now learning there's a difference between modified sine wave and pure sine wave inverters. I wasn't aware of this distinction when I made the purchase, and it turns out the 758 is a modified sine wave unit. I've since heard that modern electronics, especially things like residential refrigerators, computers, and sensitive electronic components, can be damaged by modified sine wave power.

I'm really concerned about potentially damaging my new residential refrigerator, stereo system, and computer equipment. Should I be worried about using this modified sine wave inverter with modern RV electronics? Is the hair dryer incident a sign that I need to upgrade to a pure sine wave unit, or are there other factors that could have caused this problem? I'm trying to understand if my current setup is putting my expensive electronics at risk. …more

Read answer

Engine Hard 4-6 hours 309 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Electrical Medium 2-6 hours 295 👍 1

ECM Low Battery Warning RV: Complete Diagnosis & Fix Guide

During a family trip, my 2005 Fleetwood Discovery 39S threw code 168-1 for low ECM battery voltage and went into full shutdown mode—is this dangerous with kids onboard? Engine cut out, transmission selector went dark, ABS warnings everywhere - the whole nine yards. Scared the heck out of me when it happened on the interstate!

I'm seeing this seems to be a thing with these diesel pushers, but I'm drowning in conflicting info online. Some say it's the chassis battery, others blame alternator issues, and I've even seen posts about ECM power supply problems on the Caterpillar engines. What's the actual step-by-step process to track this down? And more importantly, how do I fix it so it doesn't leave me stranded again? Really need a complete walkthrough of what causes this code and the proper repair approach. …more

Read answer

General Medium 30-60 minutes 292 👍 0

RV Liquid Spring Adjustment Guide: Setup & Tuning Tips

Three different adjustment knobs on my 2022 Tiffin Open Road 34PA's LiquidSpring suspension and I'm staring at them with zero clue about the limits.

I've got LiquidSpring suspension on all four corners, but I'm specifically wondering about the rear struts. Can I raise and lower just the rear ones independently, or am I stuck adjusting everything at once like some kind of suspension caveman? I'd love to dial in the perfect ride height and handling, but I need to know if I can fine-tune the back end separately from the front. Between the control panel and what I assume is some fancy smartphone app, surely there's a way to make this old road warrior ride like a dream without turning into a mechanical engineer, right? …more

Read answer

Solar Batteries Medium 2-4 hours 261 👍 0

RC7-GS Inverter AGM Battery Settings: Complete Setup Guide

Replaced my 105Ah AGM battery and now my RC7-GS inverter charger is completely rejecting it like this capacity doesn't exist in its programming.

The charging settings only go from 125Ah up to 1000Ah, with an 'auto' option that supposedly 'learns' my battery but resets every time the low voltage cutoff trips (which feels like cheating, honestly). I'm worried about undercharging or cooking my expensive new AGMs if I pick the wrong setting.

Oh, and while we're talking about things that don't work as advertised - the generator auto-start feature might as well be a myth. Can't even manually start the generator from the RC7 panel. At this point I'm wondering if I should have just stuck with my old setup that actually worked! Anyone know what I'm doing wrong here? …more

Read answer

Engine Easy 1-2 hours inspection 255 👍 0

Ford E450 V10 Reliability: Expected Mileage and Longevity Guide for RV Owners

Nobody prepared me for staring at this 2018 Jayco Greyhawk 29MVP with Ford E450 chassis showing 54,000 miles and wondering if I'm looking at a money pit. The unit appears well-maintained with quality features including auto-leveling, fiberglass roof and nose, plus J-ride suspension. However, the odometer shows 54,000 miles, which exceeds my initial target range.

I need to assess whether this mileage represents significant wear on the E450/V10 drivetrain combination. What is the typical service life expectation for these engines when properly maintained? At what point should mileage become a primary concern versus overall mechanical condition? …more

Read answer

Engine Easy N/A 211 👍 0

Ford V10 Triton Engine Maintenance Guide: EGR Delete vs Regular Service Tips

Spent years doing regular EGR maintenance on my old gas motorhome without issues — but this 2007 Fleetwood 31' Tioga with Ford V10 Triton has me second-guessing everything. I keep reading conflicting information about EGR delete procedures on V10 engines, and I'm worried I might make things worse if I mess with it.

Is the EGR delete modification actually necessary on this 2007 3-valve V10, or am I overthinking this? I don't want to void any warranties or create problems that weren't there before. Would I be better off just sticking to regular maintenance instead of modifications? I'm looking for reassurance that I'm taking the right approach to keep this engine running reliably for years to come. …more

Read answer

Product Ranking 8 compared

Best RV Solar Panel Kits

4.5 (12,700 reviews)

Propane Hard 6-8 hours 210 👍 0

Atwood GC10A-4E Replacement: Best Tankless RV Water Heater Upgrades 20

Halfway through draining my Atwood GC10A-4E's supposed 10-gallon capacity, the water's already running cold but my gauge shows I've only pulled maybe 6 gallons. Are there any dual-fuel tankless units that would work as a replacement? I know there's no plug-and-play option, but what are the best tankless water heaters that offer both gas and electric operation for RVs? …more

Read answer

Engine Hard Not recommended 207 👍 0

Ford V10 Turbo Kit for Motorhomes: Cost, Risks & Better Alternatives

Before every camping season rolls around, I face the same dreaded reality with my Ford V10 motorhome crawling up mountain passes like a wounded turtle. What are the realistic costs involved? Are there major risks to the engine I should know about? Is this actually worth doing or should I look at other options? …more

Read answer

Exterior Medium 30-60 min 196 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

Ac Refrigeration Medium 45 minutes 191 👍 0

Dometic 12V Refrigerator Not Cooling on Battery Power - Complete Troubleshooting Guide

Staring at my Dometic DMC compressor refrigerator that runs perfectly on 12V DC when it's cool but stops cooling completely once temperatures hit 85°F or higher. The unit works perfectly when I'm plugged into shore power at campgrounds - everything stays cold and the freezer compartment keeps items frozen solid. However, when I'm boondocking and running solely on my RV's battery bank, the performance drops significantly. The refrigerator struggles to maintain proper temperatures, and the freezer can't keep things frozen.

I have a relatively new battery setup with what should be adequate capacity for my power needs. The batteries test fine with a multimeter when the refrigerator isn't running, but I'm wondering if there's something I'm missing about power requirements or electrical connections. I've heard that 12V compressor refrigerators can be pretty demanding on battery systems, but I'm not sure what specific issues to look for.

What are the most common causes when a 12V Dometic compressor refrigerator works fine on shore power but fails to cool properly when running on batteries? I want to troubleshoot this systematically before calling in a technician. …more

Read answer

Loading more Q&A...

You've seen all 397 Q&A articles!