Results for "power supply"

Appliances Hard Professional repair required 710 👍 0

Splendide WDC7100XC Drum Bearing Repair & Replacement Guide

Splendide combo washer-dryer started making a grinding noise during the spin cycle and now it vibrates so hard it walks across the floor. Pretty sure it's the drum bearings based on the sound. Debating between a $400 repair bill and just replacing the whole unit. …more

Read answer

Engine Hard 4-6 hours 311 👍 0

Ford F53 7.5L RV Won't Start: Fuel Pump Relay Voltage Drop Fix

Woke up to my 1996 Ford F53 7.5L motorhome eating through my patience and wallet with this no-start issue that keeps coming back. It cranks strong but absolutely will not start, and I've been chasing this problem for weeks now. The engine ran fine for about 3-4 minutes one day, then just died and hasn't started since.

I've already done quite a bit of diagnostic work:
- Replaced PCM and distributor
- Fuel pump works when powered directly
- Battery is fully charged
- Checked fuses and relays
- PCM relay voltage drops from 12.2V to 9.3V with key on
- Fuel pump relay only shows 3.3V at pin 86 (should be 12V)
- Inertia switch tested at 1.7V at connector
- ANL 178 fusible link fluctuates between 0.3-0.6V

The engine will only start with starter fluid when the SPOUT is removed. I'm getting only 5.5V at the fuel pump connector.

Has anyone dealt with this specific issue on an F53 chassis? I really need to get this RV back on the road and I'm running out of ideas! …more

Read answer

Electrical Medium 2-6 hours 295 👍 1

ECM Low Battery Warning RV: Complete Diagnosis & Fix Guide

During a family trip, my 2005 Fleetwood Discovery 39S threw code 168-1 for low ECM battery voltage and went into full shutdown mode—is this dangerous with kids onboard? Engine cut out, transmission selector went dark, ABS warnings everywhere - the whole nine yards. Scared the heck out of me when it happened on the interstate!

I'm seeing this seems to be a thing with these diesel pushers, but I'm drowning in conflicting info online. Some say it's the chassis battery, others blame alternator issues, and I've even seen posts about ECM power supply problems on the Caterpillar engines. What's the actual step-by-step process to track this down? And more importantly, how do I fix it so it doesn't leave me stranded again? Really need a complete walkthrough of what causes this code and the proper repair approach. …more

Read answer

Product Ranking 8 compared

Best RV Air Conditioners

4.4 (8,100 reviews)

Ac Refrigeration Medium 45 minutes 191 👍 0

Dometic 12V Refrigerator Not Cooling on Battery Power - Complete Troubleshooting Guide

Staring at my Dometic DMC compressor refrigerator that runs perfectly on 12V DC when it's cool but stops cooling completely once temperatures hit 85°F or higher. The unit works perfectly when I'm plugged into shore power at campgrounds - everything stays cold and the freezer compartment keeps items frozen solid. However, when I'm boondocking and running solely on my RV's battery bank, the performance drops significantly. The refrigerator struggles to maintain proper temperatures, and the freezer can't keep things frozen.

I have a relatively new battery setup with what should be adequate capacity for my power needs. The batteries test fine with a multimeter when the refrigerator isn't running, but I'm wondering if there's something I'm missing about power requirements or electrical connections. I've heard that 12V compressor refrigerators can be pretty demanding on battery systems, but I'm not sure what specific issues to look for.

What are the most common causes when a 12V Dometic compressor refrigerator works fine on shore power but fails to cool properly when running on batteries? I want to troubleshoot this systematically before calling in a technician. …more

Read answer

Appliances Medium 3-4 hours 177 👍 0

Best RV Thermostatic Shower Mixing Valves 2024 - Installation Guide

According to my screaming every morning, there's this scalding burn followed by an icy shock sensation hitting my back in my RV shower. There's no middle ground - it's like my water heater has anger management issues.

I'm shopping for a thermostatic mixing valve to save myself from daily temperature shock therapy. I keep seeing mechanical models like the Symmons Temptrol and Phoenix PF213200, but honestly have no idea if they're any good. And don't get me started on those fancy digital ones like the Kohler DTV+ - they look amazing but I'm guessing they're about as RV-friendly as a pet elephant.

Anyone know which thermostatic valves actually work well in RVs without requiring me to rewire half my rig or sacrifice my firstborn to the plumbing gods? …more

Read answer

Ac Refrigeration Easy 30 minutes 177 👍 0

RV AC Freezing Up? Fix Ice on Coils in 5 Steps

Turned on my RV's AC as a total newbie and watched it run perfectly for an hour before becoming a frozen disaster that won't cool. I can literally see ice building up on the coils, and then it's game over until everything thaws out.

This has happened a few times now and I'm getting tired of sitting in a hot RV waiting for the thing to defrost. What actually causes AC units to freeze up like this? And more importantly, how do I stop it from happening again? I'm guessing it's something simple I'm missing, but I'd rather fix it right than keep dealing with this cycle. …more

Read answer

Engine Easy 15 min read 169 👍 0

Remote RV Diesel Fueling: Complete Guide for Campground Fuel Strategies

Last night at 11 PM I'm staring at my diesel RV's fuel gauge showing nearly empty — need to figure out remote campground fuel strategies before we head out this morning. With a 5 gallon Harbor Freight stick transfer pump, I've been able to add fuel when truck stops aren't convenient, but I'm concerned about static electricity risks.

My current setup involves using the pump to transfer diesel with the fuel can on a camping table, since my RV's fuel inlet is located under a slide. I pumped 10 gallons successfully, but I'm wondering about the safety of this method.

I know there are static electricity concerns when transferring fuel, and I'm curious about the specific risks with diesel. How safe is it to transfer fuel when the can isn't directly grounded to concrete? Are there best practices I should follow when manually adding diesel in remote locations? …more

Read answer

Propane Medium 45 minutes 160 👍 0

RV Gas Detector Beeps Every Minute at Night - How to Fix

Before my wife mentioned it, I had no idea our RV gas detector was beeping every single minute from 7PM to 7AM—now it's driving me absolutely crazy. It only does this during nighttime hours - never during the day. I'm plugged into shore power with 4 batteries (2 coach, 2 engine). What would cause this specific timing pattern? Is it actually detecting gas or is something else going on with the detector itself? …more

Read answer

Engine Medium 2-3 hours 158 👍 0

Ford E450 Inertia Switch Location Guide - Find Your RV's Fuel Cutoff Reset Point

Every Ford E450 I've worked on had the inertia switch behind the driver's panel — but my 2011 Freedom Elite 32r has it hidden somewhere completely different. The engine is experiencing what appears to be fuel delivery issues after a minor fender bender, and I suspect the inertia switch may have been triggered and needs to be reset.

I've already done extensive searching in the typical locations - removed both driver and passenger side kick panels completely, pulled out the glove box, and even partially disassembled sections of the dashboard. Despite checking all these common spots where Ford usually places these switches, I'm coming up empty-handed.

Could the switch be integrated into another component on this particular year and model? Are there any alternative locations specific to the E450 chassis or Freedom Elite configuration that I should be checking? I'm also wondering if some models of this year might not have a traditional standalone inertia switch at all. …more

Read answer

Ac Refrigeration Medium 4-6 hours 150 👍 0

RV 3-Way to 12V Compressor Fridge Replacement: Cut Power Use 80%

Three weeks into owning this RV and the previous owner left me with a power-hungry Norcold 3-way absorption fridge that's absolutely demolishing my 600AH battery bank daily.

I keep hearing people rave about switching to 12V compressor fridges like the Dometic DMC4101, claiming they'll solve all my power woes. But here's the thing - everyone says "it uses way less power" but nobody gives me actual numbers! I need the cold hard facts: exactly how much power will I save making this switch? Will it really make that big of a difference, or am I just trading one expensive problem for another?

Please tell me someone has real-world experience with the power consumption difference between these fridge types! …more

Read answer

Appliances Medium 2-4 hours 149 👍 0

RV Water Heater Not Hot Enough: Fix Lukewarm Water Issues

Looked forward to our two-week cross-country trip starting tomorrow until I discovered my RV water heater that used to produce scalding hot water now barely gets lukewarm. Both the electric and gas functions appear to be working - I can hear the gas igniting and see the electric indicator light - but the water temperature just won't get hot enough for a decent shower.

I've been dealing with this for weeks now and it's driving me crazy. The water gets warm, but nowhere near the hot temperatures I used to get. Is this a common problem with RV water heaters? What are the most likely culprits when you're getting lukewarm water instead of hot? I really need to figure out what's causing this and how to fix it before my next camping trip. …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Appliances Medium varies by part 148 👍 0

Furrion FMCM15-SS Microwave Parts & Repair Guide - Complete Replacement Guide

Called three RV repair shops about my dead Furrion FMCM15-SS microwave and they all want $200+ — any DIY fixes for under $50? 🤦‍♂️

I'm trying to track down replacement parts but I'm having about as much luck as finding a level campsite during peak season. Does anyone know the best places to source parts for this model? I'm particularly wondering about common failure items like door latches and turntable motors - seems like these microwaves have their favorite ways to quit on us! …more

Read answer

Engine Easy 15 minutes 142 👍 0

5 Star Tuner X4 for Ford V10 RV: Complete Performance & Upgrade Guide

Planning to tune my 2018 Ford 6.8L V10 RV but got quoted $800 for professional tuning and wondering if the 5 Star X4 is DIY-friendly. Specifically want to know about real-world performance improvements - does it actually improve throttle response and shift points? What about fuel economy gains?

Which of the 3 programs works best for RV towing? Is the investment worth it for better drivability or just hype? …more

Read answer

General Easy N/A - shopping 140 👍 0

Independent Super C Motorhome Manufacturers: Complete Guide to Non-Thor Builders

Three months of shopping and my wife just pointed out every Super C we're considering comes from Thor subsidiaries, making me realize consolidation might be trapping us with limited service options. It seems like Thor Industries and Berkshire Hathaway own practically every major motorhome brand out there now.

Before I make what could be a costly mistake, I need to know - are there actually any independent Super C manufacturers left that aren't owned by these corporate giants? I'm cautious about putting all my eggs in one basket with these mega-corporations. Should I even care about the ownership structure, or am I overthinking this? I just want to make sure I have options and aren't setting myself up for problems down the road. …more

Read answer

Electrical Medium 45 minutes 140 👍 0

RV Converter Not Charging Battery: Fix Guide & Solutions

Despite my multimeter showing 12.6 volts at the battery, everything I've read says my converter should be pushing 13.6 volts during charging. When I plug into shore power, my converter fan kicks on and runs like normal, and all my 120V stuff works fine - lights, outlets, everything. But my batteries just aren't charging at all.

I'm not really sure where to start troubleshooting this. Could it be a fuse somewhere? Bad connections? Or is my converter partially failing somehow? I'd really appreciate some guidance on what to check first and how to test if the converter is actually putting out the right voltage to charge the batteries. …more

Read answer

Loading more Q&A...

You've seen all 124 Q&A articles!