Results for "internal breaker"

Electrical Medium 2-6 hours 389 👍 4

RV Electrical Problems: 12V & 120V Troubleshooting Guide 2024

Around $500 in parts later — replaced the main breaker, cleaned all connections, checked the transfer switch — my 2007 Holiday Rambler Admiral SE still won't recognize shore power.

I'm pretty sure 110V is making it to the rig since I can measure it, but somewhere between the plug and my appliances, something's not happy. Energy management panel is dark too. What's the logical troubleshooting order here? I keep hearing about transfer switches and breaker panels but honestly don't know where to start without making things worse! …more

Read answer

Exterior Medium 30-60 min 196 👍 1

Kwikee RV Steps Not Working? Complete Troubleshooting Guide (2024)

Apparently we're leaving for a three-week cross-country trip next Monday and my Kwikee electric RV steps are still having intermittent retraction issues even after replacing both the gear box and motor. My steps are exhibiting intermittent retraction issues - they extend normally but require manual assistance to retract fully, stopping approximately a quarter inch through the cycle without intervention. I've already installed a new gear box and motor, yet the problem persists.

What systematic diagnostic approach should I follow to identify the root cause? I need to understand the complete troubleshooting sequence for motor functionality, electrical switch operation, and mechanical linkage components. Are there specific voltage measurements, resistance checks, or mechanical adjustments that should be performed to isolate whether this is an electrical or mechanical failure?

Thanks,
Pete …more

Read answer

Electrical Medium 30-90 min 190 👍 0

No 12 Volt Power in RV: Complete Troubleshooting Guide

Turned the key and nothing works on 12 volt — no lights, no water pump, no slides. Batteries show 12.6 volts on the multimeter so they're fully charged. House batteries seem fine but zero power is getting to any of the 12V circuits inside the coach. …more

Read answer

Product Ranking 8 compared

Best RV Surge Protectors

4.6 (14,200 reviews)

Ac Refrigeration Medium 2-3 hours 178 👍 0

Dometic RV AC Not Cooling? 5 Common Fixes for Air Conditioner Troubleshooting Guide

Walked out to my RV this morning trying to decide between calling a repair tech or troubleshooting my Dometic Brisk Air rooftop AC myself since it's showing weird operational issues. The compressor engages and fan motor operates normally, but the unit fails to produce cold air output. Temperature differential across the evaporator coil is minimal.

Unit functioned properly through previous cooling season with no apparent issues. Current symptoms include normal airflow volume but inadequate cooling capacity. What systematic diagnostic procedure should I follow to identify the root cause? Looking for a methodical troubleshooting sequence that addresses the most probable failure points in order of likelihood. …more

Read answer

Electrical Easy 30 minutes 173 👍 0

RV 12V Lights Dimming: Complete Troubleshooting Guide

My neighbor insists it's the converter, the RV dealer swears it's bad wiring, and every YouTube video claims it's a dying battery—but my 12V ceiling lights keep dimming! One evening they're blazing bright like a casino, the next morning they're giving off all the enthusiasm of a sleepy firefly.

I've already checked my batteries, and they seem to be charging fine and in good shape. The converter is still humming and its fan is running normally. I'm pretty sure this isn't some fancy mood lighting feature I accidentally activated (though knowing my tech skills, anything's possible). The dimming seems totally random - sometimes they're fine, sometimes they look like they're on their last legs.

I've got a basic multimeter that I pretend to know how to use, but I'm not sure where to even start poking around. As a bonus weirdness, some of my under-cabinet light switches and the wall switch for the ceiling lights are getting really hot. Anyone know what typically causes this whole disco light show situation with 12V lighting systems? …more

Read answer

Solar Batteries Medium 2-4 hours 168 👍 0

RV Battery Draining Overnight? Find & Fix Parasitic Drain

The day after I installed that new solar charge controller last month, my RV batteries started mysteriously draining from fully charged to completely dead overnight. I've already confirmed that all visible lights, fans, and appliances are turned off, and I've switched off the main interior power, but something is still drawing power continuously. I understand this is likely a parasitic drain where some component or circuit is staying energized when it shouldn't be, but I'm not sure how to systematically track down which specific circuit is causing the problem. I have a basic multimeter but I'm not entirely sure about the proper methodology for testing each circuit individually to isolate where exactly the power draw is coming from. What's the step-by-step process for using a multimeter to methodically work through the electrical system, starting from the main disconnect and testing individual fuses or circuits until I can pinpoint the exact source of this parasitic drain? …more

Read answer

Solar Batteries Medium 45 minutes 158 👍 0

RV MPPT Solar Controller E1 Error Code: Causes & Fixes

Halfway through troubleshooting my MPPT solar charge controller's E1 error — would this be covered under warranty, or am I stuck paying out-of-pocket? The controller was working fine for months, but now it's completely stopped charging my batteries and just displays this E1 fault code on the screen.

From what I've read, this could be related to battery over-voltage conditions or possibly some kind of wiring fault, but I want to make sure I understand all the potential causes before I start troubleshooting. I'm comfortable doing basic electrical work myself, but I also want to know when this might be something that requires professional attention for safety reasons.

Can someone provide a detailed breakdown of what the E1 error specifically indicates, walk me through the proper diagnostic steps to identify the root cause, and explain the repair process? I'd especially appreciate guidance on how to safely approach this troubleshooting and what warning signs would indicate I should call in an expert instead of attempting the fix myself. …more

Read answer

Solar Batteries Medium 2-4 hours 153 👍 0

How to Upgrade Your RV Converter Charger for Lithium Batteries with Gentle Care

Halfway through planning our three-week cross-country trip next month, I realized my PD4560 60-amp converter/charger won't properly handle the lithium batteries I'm installing. My existing Progressive Dynamics unit obviously isn't designed for LiFePO4 batteries - I can use boost mode to charge them up, but I know that's not ideal for battery longevity.

I just purchased a 30 amp generator and I'm wondering if it will have enough capacity to handle not just my current charger, but potentially a larger lithium-compatible unit. I'm considering upgrading to a 75 or even 90 amp charger to reduce charging times, but I need to make sure my generator can handle the load. I'm trying to figure out the actual AC amp draw of these higher-capacity chargers and whether my 30 amp generator will be sufficient.

What are the best lithium-compatible converter/charger options that would work with my generator setup, and how do I properly size the charger capacity to match my lithium battery bank? …more

Read answer

Electrical Medium 45 minutes 153 👍 0

RV Shore Power Not Working: Complete Troubleshooting Guide

Plugged into shore power at the campground last night and absolutely nothing happened — no lights, no AC, nothing. Breaker on the pedestal looks fine and my neighbor's rig is running perfectly on the same circuit. Starting to wonder if something fried inside the transfer switch. …more

Read answer

Ac Refrigeration Medium 45 minutes 148 👍 0

RV AC Making Loud Humming Noise? Fix Compressor Not Starting

Somewhere above my head, there's this loud, relentless humming grinding through the RV whenever I flip on the rooftop AC — compressor won't start but the fan spins fine.

I've been dealing with this for days now and it's driving me crazy - especially with the heat we've been having! The humming is so loud that I'm worried something might be seriously damaged. I really hope this is something I can fix myself rather than having to call out a repair tech. What could be causing a compressor to hum loudly but not start up? …more

Read answer

Solar Batteries Hard 4-6 hours 147 👍 0

MagnaSine MS2012 Inverter Replacement Guide - Best Upgrade Options 202

About my 2007 Fleetwood Bounder: the MagnaSine MS2012 manual claims it should handle my loads perfectly, but this inverter keeps failing on me anyway. It's been acting up for months now - the microwave keeps causing it to hiccup and shut off, then it comes right back on. I know it's only going to get worse from here.

I've been looking at upgrading to something more reliable, maybe a Victron or another brand, but I'm honestly overwhelmed by all the options out there. What are the best replacement inverters that other RVers have had success with? I just want something that's going to work consistently without all these random shutdowns.

Before I spend a bunch of money though, could this actually be a battery issue instead of the inverter itself? I'd hate to replace a perfectly good unit if the real problem is somewhere else in the system. …more

Read answer

Product Ranking 8 compared

Best RV Refrigerators

4.3 (9,200 reviews)

Exterior Medium 45 minutes 146 👍 0

RV Awning Won't Extend or Retract: Complete Troubleshooting & Repair Guide

This power awning manual says hold the extend button for 3 seconds, but mine's completely dead and won't budge no matter how long I hold it. When I hit the extend button, it moves out maybe 6-8 inches and then immediately retracts on its own. I have to turn the power switch off and back on each time to get even that little bit of movement.

I'm hesitant to keep forcing it since I don't want to burn out the motor or make whatever's wrong even worse. Could this be an electrical issue with low voltage, or maybe the tracks are too dirty? I've also heard about limit switches causing problems but I'm not sure how to check those safely.

What are the most common causes when an awning does this short extend-then-retract cycle? I want to start with the safest troubleshooting steps before calling a repair shop. …more

Read answer

Plumbing Easy 30-45 minutes 146 👍 0

RV Water Pump Running But No Water? Complete Troubleshooting Guide 202

Finally looking at my RV water pump right now and it's running constantly but there's absolutely zero water coming out of any faucets. However, when activating any fixture throughout the system, the water pump initiates and runs continuously without producing water flow at any outlet point.

All system components appear to be functioning mechanically - pump motor engages properly, electrical connections are secure, and there are no visible leaks in accessible plumbing runs. The symptom manifests uniformly across all water delivery points including kitchen, bathroom, and exterior service connections.

What diagnostic steps should be performed to identify the root cause of this no-flow condition despite continuous pump operation? …more

Read answer

Electrical Medium 1-2 hours 131 👍 0

Why Your RV Trips GFCI at Home But Not Campground: Complete Troubleshooting Guide

Turned on my motorhome at 11 PM and it tripped the home GFCI again — works perfectly at campgrounds but I need this solved before departure.

I've tried different adapters, rewired a busted GFCI inside the rig, even turned off ALL the breakers including the main panel breaker. Still trips my house GFCI every time, whether it's the garage, side of house, or front outlets. What gives? Why would it work everywhere else but trip GFCIs at home? There's gotta be something specific causing this, right? …more

Read answer

Electrical Easy 30 minutes 127 👍 0

RV 12V Auto Reset Breaker Size Guide: 30A, 40A, 50A Selection

Opened up my RV this morning to prep for our two-week cross-country trip tomorrow and the electrical system keeps tripping the breaker every time I run basic appliances! My RV's entire 12V system just died completely - no lights, no water pump, nothing. I've checked everything I can think of and I'm pretty sure it's the auto reset breaker that's failed.

I have a WFCO converter/charger setup with dual 6V batteries, but I can't get underneath right now to read what's stamped on the current breaker. I need to order a replacement but I'm not sure what amperage to get. I keep seeing 30A, 40A, and 50A options online but I don't want to guess wrong and either undersize it or waste money.

What's the typical auto reset breaker size for this type of setup? Is there a standard that WFCO usually pairs with dual 6V battery systems? …more

Read answer

Loading more Q&A...

You've seen all 65 Q&A articles!