Results for "front axle"

General Medium 30-60 minutes 292 👍 0

RV Liquid Spring Adjustment Guide: Setup & Tuning Tips

Three different adjustment knobs on my 2022 Tiffin Open Road 34PA's LiquidSpring suspension and I'm staring at them with zero clue about the limits.

I've got LiquidSpring suspension on all four corners, but I'm specifically wondering about the rear struts. Can I raise and lower just the rear ones independently, or am I stuck adjusting everything at once like some kind of suspension caveman? I'd love to dial in the perfect ride height and handling, but I need to know if I can fine-tune the back end separately from the front. Between the control panel and what I assume is some fancy smartphone app, surely there's a way to make this old road warrior ride like a dream without turning into a mechanical engineer, right? …more

Read answer

Engine Easy N/A 260 👍 0

Ford E-350 vs E-450 Chassis: RV Fuel Economy, Power & Weight Capacity

Last weekend I felt this awful engine strain and heard sluggish acceleration sounds while test-driving a 2017 Phoenix Cruiser #2351 with its E-350 chassis and V10 engine. I'll be doing extensive western touring through mountain and plains regions, which means substantial mountain grades and wind challenges. I'm comfortable driving slowly and want to understand two key things: 1) Will this E-350 chassis handle mountain grades without major issues, and 2) What's the real-world fuel consumption like? I plan to do an initial inspection this weekend, followed by a third-party mechanical review. I'm not overly concerned about fuel economy but want to understand the actual performance limitations. I'd appreciate insights from owners who have experience with similar touring conditions on an E-350 chassis. …more

Read answer

Plumbing Medium 1-2 hours 222 👍 0

Monaco Diplomat Rear Air Suspension Won't Dump Fully - Troubleshooting Guide

Last week my 2006 Monaco Diplomat's rear air bags started refusing to dump all the way down when I hit the air dump before leveling. The front dumps fine, but the back stays partially inflated.

I'm still pretty new to RV maintenance and not sure where to start troubleshooting this. Should I be hearing air escaping when I activate the dump? What are the most common causes when rear air bags won't dump completely? Any guidance on what to check would be really appreciated! …more

Read answer

Product Ranking 8 compared

Best RV Batteries

4.5 (15,400 reviews)

Engine Easy Planning decision 176 👍 0

RV Tire Replacement: When to Replace by Age - Complete 7 Year Rule Guide

Pulled into three different tire shops asking about RV tire replacement and got three completely different answers about when tires actually need replacing. The unit has six tires with 2018 DOT date codes, making them 7 years old as of 2025. Mileage is approximately 28,000 miles, and visual inspection shows good tread depth with no apparent cracking, bulging, or other visible deterioration.

A tire technician who performed my state inspection indicated the tires appear serviceable from an external assessment standpoint. However, I understand there may be internal degradation factors not visible during standard inspection procedures.

What is the technical consensus on replacement timing for RV tires when age limits are reached but visible condition remains acceptable? Specifically looking for guidance on the 6-7 year replacement interval and whether internal rubber compound deterioration poses legitimate safety risks regardless of external appearance. …more

Read answer

Engine Easy 15 minutes to inspect 165 👍 0

RV Tire Age Limits: Why Replace Michelin Tires After 7 Years Despite Good Tread

Called three different tire shops this month about my 2020 Newmar Ventana's Michelin 275/70R22.5 tires and all want them replaced just for being 6 years old despite perfect tread. I'm meticulous about tire maintenance - I check air pressure religiously before and after every trip, whether it's a short weekend getaway or an extended cross-country journey like the 5000-mile trip I just completed.

Despite my careful maintenance routine, I experienced a blowout on the right rear inside tire during the final leg of that recent long trip. When the roadside service technician came out to help, he recommended replacing all six tires specifically because of their age, even though the remaining tires still have plenty of tread depth and appear to be in excellent condition visually.

This has me confused because I've heard conflicting advice from other RV owners - some say well-maintained motorhome tires can safely last up to 10 years, while others insist on much shorter replacement intervals. I'm trying to understand what the actual safety guidelines are for RV tire replacement based on age versus tread wear. Should I really replace tires that still look good just because of when they were manufactured? What's the real story on how tire age affects safety, and how do I properly check the manufacturing date to make this decision? …more

Read answer

Chassis Medium 4-6 hours 157 👍 0

Ford F53 Motorhome Ride Quality: Improve Your Harsh Ride with Shocks &

I walked into my first Class A motorhome ownership with zero experience and my 2022 Jayco Precept Prestige 36H on an F53 chassis rides like I'm driving over constant speed bumps. This 3-year-old coach with 15,000 miles beats us to death on every interstate joint and bridge transition - it's honestly brutal and making long trips miserable. I've already added Sumos on the front and Timbrens on the rear, which helped somewhat with roll/sway, but I'm still getting hammered by road imperfections while blueoxing my Honda CRV.

I keep hearing conflicting advice about gas shocks versus other options, proper tire pressures, and suspension upgrades. What actually works to smooth out these bone-jarring impacts? I need real solutions that will make a noticeable difference in ride comfort, not just minor tweaks. Has anyone successfully tamed an F53's harsh ride? …more

Read answer

Engine Hard 4-6 hours installation 141 👍 0

SDI E-Clik vs Liquid Spring: Affordable F53 Chassis Suspension Upgrade Options

Nobody warned me that what started as minor swaying on highway trips last month would turn into white-knuckle driving every time I take my F53 chassis RV over 50mph. SDI E-Clik costs about a third of what Liquid Spring systems run, but I'm wondering what you actually get for that price difference.

Is E-Clik just electronic shock control, or does it offer more comprehensive suspension improvements? How does the ride quality compare between the two systems on F53 motorhomes? …more

Read answer

Engine Easy N/A - informational 138 👍 0

Toyo vs Michelin RV Tires: Complete Comparison for Diesel Pusher Motorhomes

Planning to replace the tires on my 2019 Tiffin Phaeton 40IH, and ever since I started getting quotes, everyone keeps suggesting Toyo as a cheaper alternative to Michelin.

I'm honestly a bit overwhelmed by all the tire choices and wondering if I'd be making a mistake switching brands. Will Toyo tires give me the same ride quality as the Michelins? I've heard you can save quite a bit of money, but I don't want to compromise safety or comfort since we're still learning how to handle this big rig.

Would really appreciate some guidance from those who've made this switch - are you happy with the decision or do you regret not sticking with Michelin? …more

Read answer

Chassis Medium 45 minutes 133 👍 0

Dutchstar Chassis Cracking Noise: Diagnosis & Repair Guide

Hearing a loud cracking or popping noise from underneath my Dutchstar when going over bumps or turning. Sounds structural — like metal flexing or a weld breaking. Crawled under and couldn't see any obvious cracks but the noise is getting louder each trip. …more

Read answer

Chassis Medium 3-4 hours 128 👍 0

2003 Ford F53 RV Chassis Wheel Bearing Grease Guide - Best Products &

I'm wondering if my grease choice is wrong for my 2003 Ford F53's front bearing replacement when my neighbor's identical motorhome runs perfectly after his service. The original grease that came out was a dark gray/black color and while there wasn't any catastrophic damage, the races showed enough wear marks that I decided to replace everything while I'm in there.

I've been researching different options and keep seeing conflicting recommendations. Some people swear by standard lithium grease, others recommend full synthetic formulations, and I've even seen mentions of specific brands like Valvoline MaxLife and Timken. I know the F53 chassis carries significantly more weight than a typical pickup truck, so I want to make sure I'm using something that can handle the load.

I have the torque procedure down (30 ft-lbs initial, back off, then final setting at 17 in-lbs), but I want to make sure I'm pairing that proper installation with the right grease. What specific grease products work best for the F53 front wheel bearings, and are there any compatibility issues I should be aware of when selecting a replacement grease? …more

Read answer

Chassis Hard Research and planning phase 127 👍 0

Ford F53 Godzilla V8 Suspension Problems: Fixes & Upgrades for Class A Motorhomes

Halfway through my first long trip, this bone-rattling vibration and unsettling sway started plaguing my newer Class A motorhome with the Ford F53 Godzilla V8 chassis. Coming from a 26' travel trailer and a history with brands like LazyDaze, I'm trying to understand the current RV landscape. I saw a Baystar 2023 model where the owner spent around $35,000 on suspension upgrades after just 12,000 miles.

Sounds awesome on paper, but I keep hearing people say you still need to dump a ton of money into suspension upgrades to make these things handle decently on the highway. Did Ford actually improve the suspension setup when they introduced the Godzilla engine, or are we dealing with the same basic chassis design that's been around forever? I'm talking about 30+ foot Class A rigs here - seems crazy that a $200k motorhome would need immediate aftermarket work to drive safely.

Anyone know if the Godzilla F53 combo actually fixed the handling problems or if it's just more power on the same wobbly platform? …more

Read answer

Product Ranking 8 compared

Best RV Water Heaters

4.4 (6,800 reviews)

General Hard 3-4 hours 127 👍 0

How to Replace a Broken RV Front Shock Mount - Part ID Guide

Tried to avoid a costly repair by checking first — would my RV's front shock mount bracket failure where the shock absorber connects to the chassis be covered under warranty? The bracket appears to be chassis-specific hardware, but I'm unable to locate the correct part number through standard parts diagrams - it shows as a grayed-out component without identification in the technical documentation I've found.

What is the proper procedure for identifying and sourcing this type of suspension mounting hardware? The bracket sits adjacent to part 3A010 in the assembly and appears to be a critical structural component for proper shock absorber attachment. …more

Read answer

Chassis Easy 30 minutes 123 👍 0

Ford E350 Dually Wheel Center Hole Size Guide: Front vs Rear Differences Explained

According to my mechanic, my Ford E350 dually has mismatched wheel fitments, center holes that don't align properly, AND different sizing between front and rear wheels all at once. I have a 2001 Ford E350 Class C motorhome with dual rear wheels, and I desperately need to get a spare tire sorted out.

I found what I thought was the perfect rim - same bolt pattern as my existing wheels - but when I got home and really looked at it, the center hole is noticeably smaller than the ones currently on my RV. I've been assuming all six rims on a dually setup would be identical, but now I'm second-guessing everything.

Could it be that Ford actually uses different center hole sizes between the front wheels and rear dually wheels on the E350? I'm really hoping someone can clarify this because I need to know if I bought the wrong type of rim or if there's something else I'm missing here. …more

Read answer

Chassis Easy 15 minutes 122 👍 0

Ford F53 Jounce Bumpers Always Touching: Normal Design for 20K+ GVWR Motorhomes

Finally crawling under my Ford F53 motorhome staring at these front jounce bumpers constantly touching suspension components with no clue if this means something's actually broken. According to Ford Special Service Message SSM 53453 for 2020-2025 F53 Motorhome chassis with a GVWR of 20,500-26,000 lbs, this constant contact is actually normal.

The front jounce bumpers (service base part number 3020) are designed to be an active part of the suspension, providing incremental dampening that improves ride quality and cornering performance. For motorhomes in this weight range, constant contact is not an indication of overloading or damage.

You can reference the full details in the official Ford document: https://static.nhtsa.gov/odi/tsbs/2025/MC-11015265-0001.pdf

I want to ensure I'm not damaging my suspension or operating unsafely, but this service message confirms that constant contact is within normal operating parameters for heavier motorhomes. …more

Read answer

Engine Easy 15 min visual, 1 hour full 121 👍 0

Ford F53 Motorhome Brake Inspection: Complete Guide to Checking Rotors and Pads

Turned onto that steep mountain grade last week and heard grinding from my 2014 F53 chassis, but I can't figure out how to properly inspect the brake pads and rotors. I've been crawling around under there, contorting myself into every possible position, but I just can't get a good view of the brake components through the wheel openings.

Is there a specific technique or approach that actually works for getting a proper look at the pad thickness and rotor condition? I really want to stay on top of brake maintenance, but the limited visibility is making this nearly impossible. Should I be using special tools, or is there a better method I'm missing? …more

Read answer

Loading more Q&A...

You've seen all 57 Q&A articles!