Results for "cycling"

Engine Medium 2-6 hours 466 👍 1

Onan 5500 Generator Problems: Complete Repair Guide 2024

Spent three hours testing my 2014 Hurricane's Onan 5500 gen getting 11.8 volts output when every manual says it should be 12+ volts! Here's the weird part - when I disconnect the remote harness, the generator fires right up and purrs like a kitten. But the second I plug that remote connection back in, boom - both the remote start light AND the generator start light come on, and then... nothing. Won't start at all.

The really bizarre symptom is this chattering from the fuel pump when the remote is connected. I can literally feel the fuel line jumping around when I put my hand on it. It's like the pump is having some kind of seizure or something!

I'm guessing this has to be some kind of electrical issue between the control board and the remote system, but I've never seen anything quite like this before. Anyone dealt with this specific combo of symptoms on an Onan 5500? Really hoping there's a known fix because pulling this thing out of the RV again would be a major pain! …more

Read answer

Exterior Medium 2-3 hours 214 👍 1

How to Replace RV Slide Topper Fabric: Complete DIY Guide 2024

I pulled into three different campsites this month and my torn slide topper is eating through my gear faster than I can replace it. I've never done anything like this before and I'm worried I might damage the whole mechanism or make things worse.

Can I actually replace just the fabric portion safely, or should I bite the bullet and have the entire assembly replaced by a professional? I'm also concerned about costs - I'm hoping this won't break the bank. If it is something I can do myself, how difficult is it really? I don't want to get in over my head and end up with a bigger problem than I started with.

Can you help me understand the best approach for my specific situation? …more

Read answer

Engine Easy Planning decision 177 👍 0

RV Tire Replacement: When to Replace by Age - Complete 7 Year Rule Guide

Pulled into three different tire shops asking about RV tire replacement and got three completely different answers about when tires actually need replacing. The unit has six tires with 2018 DOT date codes, making them 7 years old as of 2025. Mileage is approximately 28,000 miles, and visual inspection shows good tread depth with no apparent cracking, bulging, or other visible deterioration.

A tire technician who performed my state inspection indicated the tires appear serviceable from an external assessment standpoint. However, I understand there may be internal degradation factors not visible during standard inspection procedures.

What is the technical consensus on replacement timing for RV tires when age limits are reached but visible condition remains acceptable? Specifically looking for guidance on the 6-7 year replacement interval and whether internal rubber compound deterioration poses legitimate safety risks regardless of external appearance. …more

Read answer

Product Ranking 8 compared

Best RV Leveling Blocks & Jacks

4.6 (9,800 reviews)

General Easy 30 min maintenance 175 👍 0

RV Slide-Out Maintenance: Complete Guide to Prevent Wear and Extend Lifespan

Before I even finish extending my 2018 Newmar 2702 slide-out, there's this grinding vibration that kicks in during the final positioning phase every single time. The motor works hardest during that last foot of travel when the slide settles into place.

This observation has me questioning optimal maintenance protocols for slide-out longevity. What are the most effective strategies for reducing mechanical wear on these systems? I'm particularly interested in understanding proper usage frequency, seal maintenance requirements, and whether partial extension during routine tasks like cleaning provides any protective benefits.

Looking for comprehensive guidance on preventive maintenance practices, lubrication schedules, and storage considerations that will maximize slide-out system lifespan while minimizing premature component failure. …more

Read answer

Electrical Easy 30 minutes 173 👍 0

RV 12V Lights Dimming: Complete Troubleshooting Guide

My neighbor insists it's the converter, the RV dealer swears it's bad wiring, and every YouTube video claims it's a dying battery—but my 12V ceiling lights keep dimming! One evening they're blazing bright like a casino, the next morning they're giving off all the enthusiasm of a sleepy firefly.

I've already checked my batteries, and they seem to be charging fine and in good shape. The converter is still humming and its fan is running normally. I'm pretty sure this isn't some fancy mood lighting feature I accidentally activated (though knowing my tech skills, anything's possible). The dimming seems totally random - sometimes they're fine, sometimes they look like they're on their last legs.

I've got a basic multimeter that I pretend to know how to use, but I'm not sure where to even start poking around. As a bonus weirdness, some of my under-cabinet light switches and the wall switch for the ceiling lights are getting really hot. Anyone know what typically causes this whole disco light show situation with 12V lighting systems? …more

Read answer

Engine Easy 15 minutes to inspect 166 👍 0

RV Tire Age Limits: Why Replace Michelin Tires After 7 Years Despite Good Tread

Called three different tire shops this month about my 2020 Newmar Ventana's Michelin 275/70R22.5 tires and all want them replaced just for being 6 years old despite perfect tread. I'm meticulous about tire maintenance - I check air pressure religiously before and after every trip, whether it's a short weekend getaway or an extended cross-country journey like the 5000-mile trip I just completed.

Despite my careful maintenance routine, I experienced a blowout on the right rear inside tire during the final leg of that recent long trip. When the roadside service technician came out to help, he recommended replacing all six tires specifically because of their age, even though the remaining tires still have plenty of tread depth and appear to be in excellent condition visually.

This has me confused because I've heard conflicting advice from other RV owners - some say well-maintained motorhome tires can safely last up to 10 years, while others insist on much shorter replacement intervals. I'm trying to understand what the actual safety guidelines are for RV tire replacement based on age versus tread wear. Should I really replace tires that still look good just because of when they were manufactured? What's the real story on how tire age affects safety, and how do I properly check the manufacturing date to make this decision? …more

Read answer

Exterior Hard 2-4 hours 162 👍 0

How to Fix RV Garage Door Delamination: Complete Repair Guide 2024

Finally facing the inevitable with my 1994 Fleetwood Jamboree Rallye garage doors that are 30 years old and completely delaminating at the seams — repair or replace? The extruded aluminum frame corners that are supposed to be screwed together are failing because the screws keep breaking under stress. What started as minor separation has now progressed to the point where the structural integrity of the entire door system is compromised.

I've noticed that not only are the corner joints failing, but the door panels themselves seem to be separating from their backing material, and the weather seals around the perimeter are starting to pull away as well. The doors don't close properly anymore, leaving gaps that let in water and debris. I'm concerned about further damage to the garage area and contents if I don't address this comprehensively.

I need a complete repair approach that addresses the delamination issue, reinforces the structural components, and replaces the failing seals. Simply adding corner braces feels like a band-aid solution, and I'm worried about drilling out the broken screws without causing more damage to the aluminum frame. What's the proper way to tackle this type of comprehensive garage door repair on an older RV? …more

Read answer

Propane Medium 45 minutes 160 👍 0

RV Gas Detector Beeps Every Minute at Night - How to Fix

Before my wife mentioned it, I had no idea our RV gas detector was beeping every single minute from 7PM to 7AM—now it's driving me absolutely crazy. It only does this during nighttime hours - never during the day. I'm plugged into shore power with 4 batteries (2 coach, 2 engine). What would cause this specific timing pattern? Is it actually detecting gas or is something else going on with the detector itself? …more

Read answer

Ac Refrigeration Medium 2-3 hours 149 👍 0

Ford V10 RV Chassis A/C Cycling On and Off at High RPM - Complete Fix

Before highway driving yesterday, my gauge showed 250 PSI on the high side, but every Ford V10 manual says my 2019 Georgetown XL should max at 200 PSI. After completing full refrigerant system service including line replacement, receiver-drier, and expansion valve replacement, followed by proper evacuation and R134a charge to specification (920g), the system operates normally at idle and low RPM conditions.

However, above 2800 RPM during highway driving, the compressor cycles on and off repeatedly. System pressures appear normal during stationary testing. Is this cycling behavior a designed protective feature of the Ford V10 PCM during high load conditions, or does this indicate an underlying issue with head pressure, airflow, or refrigerant charge that requires further diagnosis? …more

Read answer

Solar Batteries Medium 2-3 hours 148 👍 0

RV Solar Panel Z Bracket Installation: Drill vs Adhesive Mounting Guide

Ready to mount solar panels on the roof but torn between drilling through the fiberglass with Z-brackets or using VHB tape adhesive mounts. Terrified of roof leaks from drill holes but also worried the adhesive won't hold at highway speeds. Which mounting method actually holds up long term? …more

Read answer

Plumbing Easy 30 minutes 148 👍 0

Fix RV Low Water Pressure on City Connection: Troubleshooting Pump Assembly

Last week my pressure regulator started reading a solid 40 PSI on city water but my water pump keeps cycling on for 5-6 seconds when everything says it should stay completely off. When I connect to city water, my water pressure regulator shows a solid 40 PSI, which should be plenty, right? But here's the weird part - my water pump keeps kicking on for about 5-6 seconds then shuts off, even though I'm connected to city water and the pump switch is supposed to be off.

The really frustrating thing is that the pressure feels weak throughout the RV, with specifically the bathroom sink and kitchen sink seeming low, though the shower has good pressure. I've already changed out the intake/check valve and don't currently have a filter in the system. I can see the pump running while on city water, which I know is not normal. I noticed the kitchen and bathroom sink screens were plugged - which might explain some pressure issues - but now I'm wondering about the toilet's low pressure. Could there be a screen in the toilet line I'm not seeing?

I've been full-timing for two years and never had this issue before. What should I be checking for? I'm handy enough to do basic repairs but need to know where to focus my troubleshooting efforts. …more

Read answer

Product Ranking 8 compared

Best RV Air Conditioners

4.4 (8,100 reviews)

Engine Medium 2-4 hours (including dealer visit) 147 👍 0

Ford F53 Motorhome Key Programming Guide: Security Features & Programming Tips

Apparently my 2008 Ford F53 motorhome is 16 years old and starting to have key programming issues — should I attempt DIY programming or call a locksmith? I just dropped $176 on two new transponder keys for my 2024 Windsport 34R (2022 F53 chassis) because I only had one set and didn't want to get locked out in the middle of nowhere wearing my pajamas and fuzzy slippers (again).

The Ford dealer quoted me another $140-170 to program these fancy chip keys, insisting I'd need to haul my 35-foot house-on-wheels down there for the programming. But the parts guy said "try them first" - and wouldn't you know it, both keys fired right up without any programming!

So what's the deal here? Are these unprogrammed transponder keys going to mysteriously stop working next Tuesday? Did I just dodge a bullet, or am I missing out on some important anti-theft features that actually matter? I'm feeling pretty smug about saving that programming fee, but also slightly paranoid that my motorhome might strand me at the worst possible moment! …more

Read answer

Exterior Medium 45 minutes 146 👍 0

RV Awning Won't Extend or Retract: Complete Troubleshooting & Repair Guide

This power awning manual says hold the extend button for 3 seconds, but mine's completely dead and won't budge no matter how long I hold it. When I hit the extend button, it moves out maybe 6-8 inches and then immediately retracts on its own. I have to turn the power switch off and back on each time to get even that little bit of movement.

I'm hesitant to keep forcing it since I don't want to burn out the motor or make whatever's wrong even worse. Could this be an electrical issue with low voltage, or maybe the tracks are too dirty? I've also heard about limit switches causing problems but I'm not sure how to check those safely.

What are the most common causes when an awning does this short extend-then-retract cycle? I want to start with the safest troubleshooting steps before calling a repair shop. …more

Read answer

Plumbing Easy 30-45 minutes 146 👍 0

RV Water Pump Running But No Water? Complete Troubleshooting Guide 202

Finally looking at my RV water pump right now and it's running constantly but there's absolutely zero water coming out of any faucets. However, when activating any fixture throughout the system, the water pump initiates and runs continuously without producing water flow at any outlet point.

All system components appear to be functioning mechanically - pump motor engages properly, electrical connections are secure, and there are no visible leaks in accessible plumbing runs. The symptom manifests uniformly across all water delivery points including kitchen, bathroom, and exterior service connections.

What diagnostic steps should be performed to identify the root cause of this no-flow condition despite continuous pump operation? …more

Read answer

Plumbing Medium 1-4 hours 145 👍 0

How to Fix RV Fresh Water Tank Leaks: Complete Diagnosis & Repair Guide

Nobody warned me how tricky RV fresh water tank leaks could be — got my tools ready and determined to fix this dripping mess under my trailer myself. The dripping was pretty steady at first but seems to have slowed down overnight to just occasional drops. My tank gauge still shows full, so I don't think it's completely emptying out.

I can see there's an underbelly cover that would need to come down to access everything underneath, but I'm hoping maybe there are some easier spots I should check first? I'd rather not tackle removing panels if I don't have to - any guidance on where these leaks typically start would be really helpful, especially near the drain valve! …more

Read answer

Loading more Q&A...

You've seen all 161 Q&A articles!